a single chip car radio integrated circuit

www.DataSheet4U.com TEF6903A Integrated car radio Rev. 01 — 13 February 2006 Preliminary data sheet 1. General description The TEF6903A is a single chip car radio integrated circuit with FM/AM tuner, stereo decoder, weak signal processing and audio processing. Radio Data System (RDS)/Radio Broadcast Data System (RBDS) demodulator for radio data reception is included. FM tuner with double conversion to IF1 = 10.7 MHz and IF2 = 450 kHz with integrated image rejection for both IF1 and IF2; integrated channel filter with variable bandwidth control; capable of US FM, Europe FM, Japan FM and Eastern Europe FM. AM tuner with double conversion to IF1 = 10.7 MHz and IF2 = 450 kHz; capable of Long Wave (LW), Medium Wave (MW) and full range Short Wave (SW) (11 m to 120 m bands). Multiplex (MPX) stereo decoder, ignition noise blanker and extensive weak signal processing. Audio processing with flexible source selection, volume, balance, fader, input gain control and inaudible tuning mute. The application of an external processor is possible. Integrated audio filters for bass and treble and loudness control function. The device can be controlled via the fast-mode I2C-bus (400 kHz) and includes autonomous tuning functions for easy control without microcontroller timing. No manual alignments are required. 2. Features s s s s s s s s s s s s s s s FM Radio Frequency (RF) front-end with large dynamic range Integrated FM channel filter with controlled bandwidth Fully integrated FM demodulator Fully integrated stereo decoder with high immunity for birdy noise FM noise blanker with adaptive detection at MPX and level Signal quality detection: level, AM wideband, frequency deviation, ultrasonic noise/adjacent channel FM weak signal processing: stereo blend, high cut control and soft mute AM RF Automatic Gain Control (AGC) control circuit for external cascode AGC and PIN diode AGC Dual AM noise blanking system AM weak signal processing: high cut control and soft mute Low phase noise local oscillator In-lock detection for optimized adaptive Phase-Locked Loop (PLL) tuning speed Crystal oscillator reference with low harmonics Inaudible soft slope tuning mute for AM and FM Sequential state machine supporting each tuning action www.DataSheet4U.com Philips Semiconductors TEF6903A Integrated car radio s s s s s s s s s Integrated RDS/RBDS radio data demodulator Flexible audio input source selection Integrated audio processing and tone filtering Treble, bass and loudness tone control Volume, balance, fader and input gain control Optional connection of external sound processor, navigation voice or beep input Audio controls with Audio Step Interpolation (ASI) for pop-free function Compact Disc (CD) dynamics compression Volume Unit (VU)-meter audio level read-out 3. Quick reference data Table 1: Symbol VCC Quick reference data Parameter analog supply voltage on pins VCC, VCCPLL, VCCVCO, VCCRF, AMMIX2OUT1, AMMIX2OUT2, MIX1OUT1 and MIX1OUT2 total supply current inclusive IV60 total supply current inclusive IV60 AM tuning frequency LW MW SW Vsens sensitivity voltage fRF = 990 kHz; m = 0.3; fmod = 1 kHz; BAF = 2.15 kHz; (S+N)/N = 26 dB; dummy aerial 15 pF/60 pF 200 µV < VRF < 1 V; m = 0.8; fAF = 400 Hz ∆f = 40 kHz Conditions Min 8 Typ 8.5 Max 9 Unit V Supply voltage Supply current in FM mode ICC ICC ftune 144 522 2.3 102 89 50 288 1710 26.1 mA mA kHz kHz MHz µV Supply current in AM mode AM overall system parameters S/N THD IP3 ftune Vsens ultimate signal-to-noise ratio total harmonic distortion 3rd-order intercept point FM tuning frequency sensitivity voltage (RF input voltage at (S+N)/N = 26 dB) ∆f = 22.5 kHz; fmod = 1 kHz; DEMP = 1; B = 300 Hz to 22 kHz; measured with 75 Ω dummy antenna and test circuit 54 65 - 58 0.4 130 2 1 108 - dB % dBµV MHz µV FM overall system parameters (S+N)/N maximum signal plus noise-to-noise Vi = 3 mV; ∆f = 22.5 kHz; ratio of MPXAM output voltage fmod = 1 kHz; DEMP = 1; B = 300 Hz to 22 kHz; measured with 75 Ω dummy antenna and test circuit total harmonic distortion ∆f = 75 kHz - 60 - dB THD TEF6903A_1 - 0.5 1 % © Koninklijke Philips Electronics N.V. 2006. All rights reserved. Preliminary data sheet Rev. 01 — 13 February 2006 2 of 110 www.DataSheet4U.com Philips Semiconductors TEF6903A Integrated car radio Table 1: Symbol IP3 αcs S/N Quick reference data…continued Parameter 3rd-order intercept point channel separation signal-to-noise ratio Conditions ∆f = 400 kHz fFMMPX = 1 kHz fMPXAMIN = 20 Hz to 15 kHz; referenced to 1 kHz at 91 % FM modulation; DEMP = 1 FM mode; DEMP = 1; measured with 15 kHz brick-wall low-pass filter; fMPXAMIN = 200 Hz to 15 kHz THD = 0.2 %; Gvol = −6 dB; pins INAL, INAR, INAC, INAD, INBL, INBR, INC and IND configured as non-inverting, single ended inputs; faudio = 20 Hz to 10 kHz; Vi = 1 V (RMS) see Table 83 maximum setting minimum setting [1] [1] Min 40 70 Typ 120 - Max - Unit dBµV dB dB Stereo decoder path THD total harmonic distortion - - 0.3 % Tone/volume control Vi(max) maximum input voltage 2 V THD total harmonic distortion - 0.02 0.1 % Gvol volume/balance gain control - 20 −75 1 14 −14 2 14 −14 2 - dB dB dB dB dB dB dB dB dB Gstep(vol) Gtreble step resolution treble gain control TRE[2:0] = 111; TREM = 1 TRE[2:0] = 111; TREM = 0 Gstep(treble) step resolution gain Gbass Gstep(bass) [1] bass gain control step resolution gain BAS[3:0] = 0111; BAM = 1 BAS[3:0] = 0111; BAM = 0 The input gain setting ING and the volume setting VOL define the overall volume. The overall range is limited to −83 dB to +28 dB. For values > +28 dB the actual value is +28 dB. For overall values < −83 dB the actual value is mute. 4. Ordering information Table 2: Ordering information Package Name TEF6903AH QFP80 Description Version plastic quad flat package; 80 leads (lead length 1.6 mm); body 14 × 14 × 2.7 mm SOT496-1 Type number TEF6903A_1 © Koninklijke Philips Electronics N.V. 2006. All rights reserved. Preliminary data sheet Rev. 01 — 13 February 2006 3 of 110 xxxx xxxxxxxxxxxxxxxxxxxxxxxxxxxxxx x xxxxxxxxxxxxxx xxxxxxxxxx xxx xxxxxx xxxxxxxxxxxxxxxxxxxxxxx xxxxxxxxxxxxxxxxxxxxxx xxxxx xxxxxx xx xxxxxxxxxxxxxxxxxxxxxxxxxxxxx xxxxxxxxxxxxxxxxxxxxxx xxxxxxxxxxx xxxxxxx xxxxxxxxxxxxxxxxxxx xxxxxxxxxxxxxxxx xxxxxxxxxxxxxx xxxxxx xx xxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxx xxxxxxxxxxxxxxxxxxxxxxxx xxxxxxx xxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxx xxxxxxxxxxx xxxxx x x Preliminary data sheet Rev. 01 — 13 February 2006 © Koninklijke Philips Electronics N.V. 2006. All rights reserved. TEF6903A_1 XTAL2 XTAL1 63 62 MPXAMOUT MPXAMIN 76 75 PROUT n.c. 72, 73, 74 INAL INAR INAC INAD INBL INBR INC 71 70 69 68 67 66 65 IND 64 PLOUT 54 53 INPL 56 INPR 55 61 60 59 58 57 from/to EXP SEL. 1, 2 ana FM STEREO DECODER DIV fREF VCOFDB 78 LO2 90° 79 PLL ÷N BAND ÷M LO1 90° Φ antenna DAA VCCPLL PLLGND i.c. VTCM VTC n.c. DAAOUT FMMIX1IN1 3 4 5 6 7 pll pll i.c. vcm LEVEL vcc FM DEMODULATOR gnd vref FMMIX1IN2 16 40 25 iFM LO1 FM/AM RF AGC iAM rf 17 rf 18 38 19 i.c. dc 20 21 CASCODE CONTROL 22 23 MIXER mix1 26 if1 29 MIXER AM DEMODULATOR www.DataSheet4U.com 5. Block diagram Philips Semiconductors AGND LFOUT RFOUT LROUT RROUT VCCVCO 77 vco ÷2 NOISE BLANKER HIGH CUT DE-EMPHASIS 50 µs/75 µs INPUT SELECT EXP SEL. 1 INPUT GAIN, VOLUME, BALANCE, MUTE LOUDNESS, BASS, TREBLE EXP SEL. 2 F/R FADER hcc snc SNC HCC SM soft mute AUDIO STEP INTERPOLATION 52 tuning mute TUNING STATE MACHINE I2C-BUS 50 swap 49 SDA ADDR VCOTNK VCOGND USN AM NOISE DETECTOR MOD OFFS FM NOISE DETECTOR WAM 80 vco CPOUT VTUNE 1 2 MULTIPATH, LEVEL, ADJACENT CHANNEL, MODULATION AND OFFSET DETECTION WEAK SIGNAL AND FM BANDWIDTH CONTROL LOGIC BW 51 SCL reset hold fast readhold dig RDS RDS DEMODULATOR rds DGND 48 47 46 RDCL RDDA RDSGND vtc 10 to 13 14 15 MIXER LO1 90° 90° 45 TEF6903AH LEVEL VCC GND VREF V60 LO2 90° 90° ifbw 44 43 42 41 MIXER AM IF NOISE DETECTOR IF COUNT LO2 6v IFMAGC 8 TRFAGC 9 24 25 27 28 34 35 36 37 38 39 40 30, 31, 32, 33 008aaa000 TEF6903A VCCRF RFGND IAMAGC VDCPIN i.c. VAMCAS AMMIX1DEC AMMIX1REF MIX1OUT2 IF1DEC IF1IN AMMIX2OUT1 TAMIFKAGC AMIF2IN n.c. Integrated car radio VAMCASFB AMMIX1IN MIX1OUT1 IFGND AMMIX2OUT2 AMIF2DEC 4 of 110 Fig 1. Block diagram of TEF6903AH www.DataSheet4U.com Philips Semiconductors TEF6903A Integrated car radio 6. Pinning information 6.1 Pinning 76 MPXAMOUT 75 MPXAMIN 80 VCOGND 77 VCCVCO 79 VCOTNK 78 VCOFDB 63 XTAL2 62 XTAL1 70 INAR 69 INAC 68 INAD 66 INBR 71 INAL 67 INBL 65 INC CPOUT VTUNE VCCPLL PLLGND i.c. VTCM VTC IFMAGC TRFAGC 1 2 3 4 5 6 7 8 9 64 IND 74 n.c. 73 n.c. 72 n.c. 61 AGND 60 LFOUT 59 RFOUT 58 LROUT 57 RROUT 56 INPL 55 INPR 54 PLOUT 53 PROUT 52 ADDR 51 SCL 50 SDA 49 DGND 48 RDCL 47 RDDA 46 RDSGND 45 LEVEL 44 VCC 43 GND 42 VREF 41 V60 AMIF2IN 40 008aaa001 n.c. 10 n.c. 11 n.c. 12 n.c. 13 DAAOUT 14 FMMIX1IN1 15 FMMIX1IN2 16 VCCRF 17 RFGND 18 IAMAGC 19 i.c. 20 VDCPIN 21 VAMCASFB 22 VAMCAS 23 AMMIX1DEC 24 AMMIX1IN 25 AMMIX1REF 26 MIX1OUT1 27 MIX1OUT2 28 TEF6903AH IFGND 29 n.c. 30 n.c. 31 n.c. 32 n.c. 33 IF1DEC 34 IF1IN 35 AMMIX2OUT1 36 AMMIX2OUT2 37 TAMIFKAGC 38 Fig 2. Pin configuration for QFP80 6.2 Pin description Table 3: Symbol CPOUT VTUNE VCCPLL PLLGND i.c. VTCM VTC TEF6903A_1 Pin description Pin 1 2 3 4 5 6 7 Description charge pump output tuning voltage; 3 mA charge pump output tuning PLL supply voltage PLL ground internally connected; leave open IF filter reference voltage IF filter center voltage © Koninklijke Philips Electronics N.V. 2006. All rights reserved. Preliminary data sheet Rev. 01 — 13 February 2006 AMIF2DEC 39 5 of 110 www.DataSheet4U.com Philips Semiconductors TEF6903A Integrated car radio Pin description…continued Pin 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 D