a single chip car radio integrated circuit

www.DataSheet4U.com TEF6901A Integrated car radio Rev. 01 — 2 February 2006 Preliminary data sheet 1. General description The TEF6901A is a single chip car radio integrated circuit with FM/AM tuner, stereo decoder, weak signal processing and audio processing. Radio Data System (RDS)/Radio Broadcast Data System (RBDS) demodulator for radio data reception is included. FM tuner with double conversion to IF1 = 10.7 MHz and IF2 = 450 kHz with integrated image rejection for both IF1 and IF2; integrated channel filter with variable bandwidth control; capable of US FM, Europe FM, Japan FM and Eastern Europe FM. AM tuner with double conversion to IF1 = 10.7 MHz and IF2 = 450 kHz; capable of Long Wave (LW), Medium Wave (MW) and full range Short Wave (SW) (11 m to 120 m bands). Multiplex (MPX) stereo decoder, ignition noise blanker and extensive weak signal processing. Audio processing with flexible source selection, volume, balance, fader, input gain control and inaudible tuning mute. Integrated audio filters for bass and treble and loudness control function. The device can be controlled via the fast-mode I2C-bus (400 kHz) and includes autonomous tuning functions for easy control without microcontroller timing. No manual alignments are required. 2. Features s s s s s s s s s s s s s s s FM Radio Frequency (RF) front-end with large dynamic range Integrated FM channel filter with controlled bandwidth Fully integrated FM demodulator Fully integrated stereo decoder with high immunity for birdy noise FM noise blanker with adaptive detection at MPX and level Signal quality detection: level, AM wideband, frequency deviation, ultrasonic noise/adjacent channel FM weak signal processing: stereo blend, high cut control and soft mute AM RF Automatic Gain Control (AGC) control circuit for external cascode AGC and PIN diode AGC Dual AM noise blanking system AM weak signal processing: high cut control and soft mute Low phase noise local oscillator In-lock detection for optimized adaptive Phase-Locked Loop (PLL) tuning speed Crystal oscillator reference with low harmonics Inaudible soft slope tuning mute for AM and FM Sequential state machine supporting each tuning action www.DataSheet4U.com Philips Semiconductors TEF6901A Integrated car radio s s s s s s s s Integrated RDS/RBDS radio data demodulator Flexible audio input source selection Integrated audio processing and tone filtering Treble, bass and loudness tone control Volume, balance, fader and input gain control Audio controls with Audio Step Interpolation (ASI) for pop-free function Compact Disc (CD) dynamics compression Volume Unit (VU)-meter audio level read-out 3. Quick reference data Table 1: Symbol VCC Quick reference data Parameter analog supply voltage on pins VCC, VCCPLL, VCCVCO, VCCRF, AMMIX2OUT1, AMMIX2OUT2, MIX1OUT1 and MIX1OUT2 total supply current inclusive IV60 total supply current inclusive IV60 AM tuning frequency LW MW SW Vsens sensitivity voltage fRF = 990 kHz; m = 0.3; fmod = 1 kHz; BAF = 2.15 kHz; (S+N)/N = 26 dB; dummy aerial 15 pF/60 pF 200 µV < VRF < 1 V; m = 0.8; fAF = 400 Hz ∆f = 40 kHz Conditions Min 8 Typ 8.5 Max 9 Unit V Supply voltage Supply current in FM mode ICC ICC ftune 144 522 2.3 102 89 50 288 1710 26.1 mA mA kHz kHz MHz µV Supply current in AM mode AM overall system parameters S/N THD IP3 ftune Vsens ultimate signal-to-noise ratio total harmonic distortion 3rd-order intercept point FM tuning frequency sensitivity voltage (RF input voltage at (S+N)/N = 26 dB) ∆f = 22.5 kHz; fmod = 1 kHz; DEMP = 1; B = 300 Hz to 22 kHz; measured with 75 Ω dummy antenna and test circuit 54 65 - 58 0.4 130 2 1 108 - dB % dBµV MHz µV FM overall system parameters (S+N)/N maximum signal plus noise-to-noise Vi = 3 mV; ∆f = 22.5 kHz; ratio of MPXAM output voltage fmod = 1 kHz; DEMP = 1; B = 300 Hz to 22 kHz; measured with 75 Ω dummy antenna and test circuit total harmonic distortion 3rd-order intercept point ∆f = 75 kHz ∆f = 400 kHz - 60 - dB THD IP3 TEF6901A_1 - 0.5 120 1 - % dBµV © Koninklijke Philips Electronics N.V. 2006. All rights reserved. Preliminary data sheet Rev. 01 — 2 February 2006 2 of 107 www.DataSheet4U.com Philips Semiconductors TEF6901A Integrated car radio Table 1: Symbol αcs S/N Quick reference data…continued Parameter channel separation signal-to-noise ratio Conditions fFMMPX = 1 kHz fMPXAMIN = 20 Hz to 15 kHz; referenced to 1 kHz at 91 % FM modulation; DEMP = 1 FM mode; DEMP = 1; measured with 15 kHz brick-wall low-pass filter; fMPXAMIN = 200 Hz to 15 kHz THD = 0.2 %; Gvol = −6 dB; pins INAL, INAR, INAC, INBL, INBR, INC and IND configured as non-inverting, single ended inputs; faudio = 20 Hz to 10 kHz; Vi = 1 V (RMS) see Table 83 maximum setting minimum setting [1] [1] Min 40 70 Typ - Max - Unit dB dB Stereo decoder path THD total harmonic distortion - - 0.3 % Tone/volume control Vi(max) maximum input voltage 2 V THD total harmonic distortion - 0.02 0.1 % Gvol volume/balance gain control - 20 −75 1 14 −14 2 14 −14 2 - dB dB dB dB dB dB dB dB dB Gstep(vol) Gtreble step resolution treble gain control TRE[2:0] = 111; TREM = 1 TRE[2:0] = 111; TREM = 0 Gstep(treble) step resolution gain Gbass Gstep(bass) [1] bass gain control step resolution gain BAS[3:0] = 0111; BAM = 1 BAS[3:0] = 0111; BAM = 0 The input gain setting ING and the volume setting VOL define the overall volume. The overall range is limited to −83 dB to +28 dB. For values > +28 dB the actual value is +28 dB. For overall values < −83 dB the actual value is mute. 4. Ordering information Table 2: Ordering information Package Name TEF6901AH QFP64 Description Version plastic quad flat package; 64 leads (lead length 1.6 mm); body 14 × 14 × 2.7 mm SOT393-1 Type number TEF6901A_1 © Koninklijke Philips Electronics N.V. 2006. All rights reserved. Preliminary data sheet Rev. 01 — 2 February 2006 3 of 107 xxxx xxxxxxxxxxxxxxxxxxxxxxxxxxxxxx x xxxxxxxxxxxxxx xxxxxxxxxx xxx xxxxxx xxxxxxxxxxxxxxxxxxxxxxx xxxxxxxxxxxxxxxxxxxxxx xxxxx xxxxxx xx xxxxxxxxxxxxxxxxxxxxxxxxxxxxx xxxxxxxxxxxxxxxxxxxxxx xxxxxxxxxxx xxxxxxx xxxxxxxxxxxxxxxxxxx xxxxxxxxxxxxxxxx xxxxxxxxxxxxxx xxxxxx xx xxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxx xxxxxxxxxxxxxxxxxxxxxxxx xxxxxxx xxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxxx xxxxxxxxxxx xxxxx x x Preliminary data sheet Rev. 01 — 2 February 2006 © Koninklijke Philips Electronics N.V. 2006. All rights reserved. TEF6901A_1 XTAL2 XTAL1 51 50 MPXAMOUT MPXAMIN 60 59 INAL INAR INAC 58 57 56 INBL INBR INC 55 54 53 IND 52 AUDIO STEP INTERPOLATION ana FM STEREO DECODER DIV fREF VCOFDB 62 LO2 90° 63 PLL ÷N BAND ÷M LO1 90° Φ antenna DAA VCCPLL PLLGND i.c. VTCM VTC 3 4 5 6 7 pll pll i.c. vcm vtc LO1 90° 90° MIXER 12 32 21 iFM LO1 FM/AM RF AGC iAM rf 13 rf 14 30 15 i.c. dc 16 17 CASCODE CONTROL 18 19 MIXER mix1 22 if1 25 MIXER LEVEL vcc FM DEMODULATOR gnd vref FMMIX1IN2 AM IF NOISE DETECTOR 6v AM NOISE DETECTOR MOD OFFS FM NOISE DETECTOR WAM USN SNC HCC SM tuning mute TUNING STATE MACHINE I2C-BUS 42 swap 41 SDA ÷2 hcc snc 44 ADDR soft mute NOISE BLANKER HIGH CUT DE-EMPHASIS 50 µs/75 µs INPUT SELECT INPUT GAIN, VOLUME, BALANCE, MUTE LOUDNESS, BASS, TREBLE F/R FADER 49 48 47 46 45 AGND LFOUT RFOUT LROUT RROUT VCCVCO 61 vco VCOTNK VCOGND 64 vco CPOUT VTUNE 1 2 MULTIPATH, LEVEL, ADJACENT CHANNEL, MODULATION AND OFFSET DETECTION WEAK SIGNAL AND FM BANDWIDTH CONTROL LOGIC BW 43 SCL reset hold fast readhold dig RDS RDS DEMODULATOR rds DGND 40 39 38 RDCL RDDA RDSGND 37 www.DataSheet4U.com 5. Block diagram Philips Semiconductors TEF6901AH LEVEL VCC GND VREF V60 LO2 90° 90° DAAOUT FMMIX1IN1 10 11 ifbw 36 35 34 33 MIXER IF COUNT LO2 AM DEMODULATOR IFMAGC 8 TRFAGC 9 20 21 23 24 26 27 28 29 30 31 32 008aaa002 TEF6901A VCCRF RFGND IAMAGC VDCPIN i.c. VAMCAS AMMIX1DEC AMMIX1REF MIX1OUT2 IF1DEC IF1IN AMMIX2OUT1 TAMIFKAGC AMIF2IN Integrated car radio VAMCASFB AMMIX1IN MIX1OUT1 IFGND AMMIX2OUT2 AMIF2DEC 4 of 107 Fig 1. Block diagram of TEF6901AH www.DataSheet4U.com Philips Semiconductors TEF6901A Integrated car radio 6. Pinning information 6.1 Pinning 60 MPXAMOUT 59 MPXAMIN 64 VCOGND 61 VCCVCO 63 VCOTNK 62 VCOFDB 51 XTAL2 50 XTAL1 CPOUT VTUNE VCCPLL PLLGND i.c. VTCM VTC IFMAGC TRFAGC 1 2 3 4 5 6 7 8 9 49 AGND 48 LFOUT 47 RFOUT 46 LROUT 45 RROUT 44 ADDR 43 SCL 42 SDA 41 DGND 40 RDCL 39 RDDA 38 RDSGND 37 LEVEL 36 VCC 35 GND 34 VREF 33 V60 AMIF2IN 32 008aaa003 57 INAR 56 INAC 54 INBR IF1IN 27 58 INAL 55 INBL 53 INC AMMIX2OUT1 28 TEF6901AH DAAOUT 10 FMMIX1IN1 11 FMMIX1IN2 12 VCCRF 13 RFGND 14 IAMAGC 15 i.c. 16 VDCPIN 17 VAMCASFB 18 VAMCAS 19 AMMIX1DEC 20 AMMIX1IN 21 AMMIX1REF 22 MIX1OUT1 23 MIX1OUT2 24 IFGND 25 IF1DEC 26 AMMIX2OUT2 29 TAMIFKAGC 30 AMIF2DEC 31 Fig 2. Pin configuration for QFP64 6.2 Pin description Table 3: Symbol CPOUT VTUNE VCCPLL PLLGND i.c. VTCM VTC IFMAGC TRFAGC DAAOUT TEF6901A_1 Pin description Pin 1 2 3 4 5 6 7 8 9 10 Description charge pump output tuning voltage; 3 mA charge pump output tuning PLL supply voltage PLL ground internally connected; leave open Intermediate Frequency (IF) filter reference voltage IF filter center voltage PIN diode current FM AGC FM and AM RF AGC time constant antenna Digital Auto Alignment (DAA) output © Koninklijke Philips Electronics N.V. 2006. All rights reserved. Preliminary data sheet Rev. 01 — 2 February 2006 52 IND 5 of 107 www.DataSheet4U.com Philips Semiconductors TEF6901A Integrated car radio Pin description…continued Pin 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 Description FM mixer 1 input 1 FM mixer 1 input 2 AM/FM RF supply voltage RF ground PIN diode current AMAGC internally connected; leave open AM PIN diode DC bias voltage feedback for cascode AM AGC cascode AM AGC AM mixer 1 decoupling AM mixer 1 input AM mixer 1 reference AM and FM mixer 1 output 1 at IF1