Triacs

www.DataSheet4U.com DBT138F-600 UL No. E256958 Triac / Sensitive Gate Symbol Features Repetitive Peak Off-State Voltage : 600V R.M.S On-State Current ( IT(RMS)= 12 A ) High Commutation dv/dt Sensitive Gate Triggering 3 Mode ( IGT = 10mA) Isolation Voltage ( VISO = 2500V AC ) 2.T2 BVDRM = 600V IT(RMS) = 12 A 3.Gate 1.T1 ITSM = 110 A TO-220F General Description This device is fully isolated package suitable for sensitive gate triggering , direct coupling to TTL, HTL, CMOS and application such as various logic functions,medium power AC switching applications, such as fan speed control, lighting controllers and home appliance equipment. 1 2 3 Absolute Maximum Ratings Symbol VDRM IT(RMS) ITSM I2 t PGM PG(AV) IGM VGM VISO TJ TSTG ( TJ = 25°C unless otherwise specified ) Condition Sine wave, 50 to 60 Hz,Gate Open TC = 58 °C One Cycle, 50Hz/60Hz, Peak, Non-Repetitive t =10ms TC =58 °C, Pulse width Over any 20ms period tp = 20us, TJ=125°C tp = 20us, TJ=125°C A.C. 1 minute 1.0us Parameter Repetitive Peak Off-State Voltage R.M.S On-State Current Surge On-State Current I2t for fusing Peak Gate Power Dissipation Average Gate Power Dissipation Peak Gate Current Peak Gate Voltage Isolation Breakdown Voltage(R.M.S.) Operating Junction Temperature Storage Temperature Mass Ratings 600 12 100/110 50 5.0 0.5 2.0 10 2500 - 40 ~ 125 - 40 ~ 150 2.0 Units V A A A2 s W W A V V °C °C g July , 2005. Rev. 1 copyright@ D&I Semiconductor Co., Ltd., All rights reserved. 1/6 www.DataSheet4U.com DBT138F-600 Electrical Characteristics Symbol Items Repetitive Peak Off-State Current Peak On-State Voltage Conditions VD = VDRM, Single Phase, Half Wave TJ = 125 °C IT = 15 A, Inst. Measurement Ratings Min. Typ. Max. 2.0 1.65 10 10 Unit IDRM VTM I+GT1 I -GT1 mA V Gate Trigger Current I -GT3 I+GT3 V+GT1 V-GT1 Gate Trigger Voltage V-GT3 V+GT3 VGD (dv/dt)c IH Rth(j-c) IV Non-Trigger Gate Voltage Critical Rate of Rise Off-State Voltage at Commutation Holding Current Thermal Impedance IV VD = 6 V, RL=10 10 25 1.5 1.5 VD = 6 V, RL=10 1.5 2.5 TJ = 125 °C, VD = 1/2 VDRM TJ = 125 °C, [di/dt]c = -4.0 A/ms, VD=2/3 VDRM 0.2 10 15 Junction to case 3.7 mA V V V/ mA °C/W 2/6 www.DataSheet4U.com DBT138F-600 Fig 1. Gate Characteristics 10 2 Fig 2. On-State Voltage 10 1 VGM (10V) On-State Current [A] Gate Voltage [V] PGM (5W) PG(AV) (0.5W) 25 10 0 10 1 TJ = 125 C o IGM (2A) TJ = 25 C 10 0 o 10 -1 VGD (0.2V) 1 10 10 2 10 3 0.5 1.0 1.5 2.0 2.5 3.0 3.5 Gate Current [mA] On-State Voltage [V] Fig 3. On State Current vs. Maximum Power Dissipation 20 18 130 Fig 4. On State Current vs. Allowable Case Temperature Allowable Case Temperature [ oC] o o o θ = 180 2 120 110 100 90 2 Power Dissipation [W] 16 14 12 10 8 6 4 2 0 0 3 360° θ = 150 θ = 120 o θ = 90 θ = 60 θ = 30 o o : Conduction Angle θ = 30 θ = 60 θ θ θ θ 7 8 9 10 11 12 o o o 80 70 60 50 360° : Conduction Angle = 90 o = 120 o = 150 o = 180 13 14 15 6 9 12 15 0 1 2 3 4 5 6 RMS On-State Current [A] RMS On-State Current [A] Fig 5. Surge On-State Current Rating ( Non-Repetitive ) 120 Fig 6. Gate Trigger Voltage vs. Junction Temperature 10 100 Surge On-State Current [A] 80 o 60Hz 60 VGT (25 C) VGT (t C) o 1 40 50Hz 20 0 0 10 10 1 10 2 0.1 -50 0 50 100 o 150 Time (cycles) Junction Temperature [ C] 3/6 www.DataSheet4U.com DBT138F-600 Fig 7. Gate Trigger Current vs. Junction Temperature 10 10 Fig 8. Transient Thermal Impedance 1 I I + GT1 _ GT1 Transient Thermal Impedance [ C/W] IGT (t C) o IGT (25 C) o o 1 I _ GT3 0.1 -50 0 50 100 o 150 0.1 -2 10 10 -1 10 0 10 1 10 2 Junction Temperature [ C] Time (sec) Fig 9. Gate Trigger Characteristics Test Circuit 10 10 10 6V V A 6V A V 6V A V RG RG RG Test Procedure Test Procedure Test Procedure 4/6 www.DataSheet4U.com DBT138F-600 TO-220F Package Dimension mm Typ. Inch Typ. Dim. A B C D E F G H I J K L M N O 1 2 Min. 10.4 6.18 9.55 13.47 6.05 1.26 3.17 1.87 2.57 Max. 10.6 6.44 9.81 13.73 6.15 1.36 3.43 2.13 2.83 Min. 0.409 0.243 0.376 0.530 0.238 0.050 0.125 0.074 0.101 Max. 0.417 0.254 0.386 0.540 0.242 0.054 0.135 0.084 0.111 2.54 5.08 2.51 1.25 0.45 0.6 3.7 3.2 1.5 2.62 1.55 0.63 1.0 0.099 0.049 0.018 0.024 0.100 0.200 0.103 0.061 0.025 0.039 0.146 0.126 0.059 F B A E H I 1 C L 1 D 2 3 J K M 2 G 1. T1 2. T2 3. Gate N O 5/6 www.DataSheet4U.com DBT138F-600 TO-220F Package Dimension, Forming mm Typ. Inch Typ. Dim. A B C D E F G H I J K L M N O P 1 2 Min. 10.4 6.18 9.55 8.4 6.05 1.26 3.17 1.87 2.57 Max. 10.6 6.44 9.81 8.66 6.15 1.36 3.43 2.13 2.83 Min. 0.409 0.243 0.376 0.331 0.238 0.050 0.125 0.074 0.101 Max. 0.417 0.254 0.386 0.341 0.242 0.054 0.135 0.084 0.111 2.54 5.08 2.51 1.25 0.45 0.6 5.0 3.7 3.2 1.5 2.62 1.55 0.63 1.0 0.099 0.049 0.018 0.024 0.100 0.200 0.103 0.061 0.025 0.039 0.197 0.146 0.126 0.059 F B A E H I 1 C L 1 2 3 N J K O P M 2 G D 1. T1 2. T2 3. Gate 6/6